Heated seat problems Ford Freestyle, Five Hundred, Montego?

  • Some 2005-2006 Freestyle, Five Hundred, and Montego vehicles built through 11/22/2005 may exhibit a non-functioning heated driver’s seat. This may be due to seat cushion heater harness becoming trapped between the track torsion bar and the cushion when the seat is in the rear tilt full down position.

Why has my heated seat stopped working?

It’s common for the heating element to be the main reason a heated seat isn’t working, simply because the heating wire that warms the seat is delicate and tends to break. If the heating element is partially or totally damaged, you’ll likely need to replace the entire unit.

How do you reset heated seats?

How to Reset the Control Module

  1. Move the Seat Forward. Move the seat forward all the way to access the seat’s connector.
  2. Pry Up the Electrical Connector from the Carpet. Pry up the electrical connector from the carpet with a trim tool.
  3. Disconnect the Connector for 5 Minutes.
  4. Reinstall the Connector.
  5. Test the Seat Warmers.

Where is the heated seat button located?

Normally the buttons are located on the side of the driver and passenger door. In some vehicles, just the bottom of the seat warms up, where in others both the bottom and back warm up.

Can you repair heated seats?

A heated seat repair cost can vary widely depending on the vehicle and exactly what’s wrong, but in general, it’s not inexpensive, primarily because of the time required to diagnose and repair the problem, which almost always involves removing the seat from the vehicle.

How much does it cost to install heated seats?

Nearly any vehicle can have heated seats installed. The kits are simple, the installation is straightforward, and the cost is surprisingly affordable (under $500 for most applications).

How long does it take for heated seats to warm up?

It might take a few minutes for the seats to reach their maximum heat level, so if you like to let the car warm-up for a few minutes on cold mornings, consider activating the seat heaters at the same time for a comfortable and cozy ride.

How do you test a heater with a multimeter?

Touch one of the multimeter probes to the loosened screw. Touch the other probe to the other screw attached to the face of the heating element. If the heating element is functioning properly, the multimeter should read between 10 and 30 ohms.

How does a heated seat in a car work?

Heated seats are powered by a heating element, a long strip of material that functions as a resistor. A resistor resists the flow of electricity. When electric current flows through it, the energy is turned into heat, which flows through the seat, warming the rider.

Are Heated seats in cars bad for you?

According to WTOP News, the repeated use of heated seats could lead to “ erythema ab igne” — Latin for “redness from fire.” Another name doctors call it is “toasted skin syndrome” or “TSS.” The symptoms can come on slowly, and by the time the skin hurts enough to notice, there’s already significant damage.

Does having heated seats use more fuel?

The answer is yes, your car heater does use fuel to operate. But it recycles heat which is already being used to power the car from the engine, so the extra fuel used by the heaters won’t be an excessive amount. Then the coolant will be diverted to the heater core inside the cabin, and heat will be generated.

Heated seat problems Ford Freestyle, Five Hundred, Montego

For the following models, Ford has issued a technical service bulletin (TSB)06-2-11 to address concerns with the heated seats: Freestyle, Five Hundred, and Montego were all constructed between 2005-06 to 11/22/2005. When the seat is fully tilted down in the back, it is possible that the heater harness becomes entangled between the track torsion bar and the cushion, resulting in the problem being produced. The soldered junction at the heating pad is damaged as a result of this. The remedy is replacing the seat pad with a new component number and rerouting the harness in order to avoid the problem from occurring again in the future.

You’ll need different pads for the back of the seat and the bottom of the seat.

That’s a piece of cake.

Then you can get to the four nuts that are holding the seat in place and remove them.

To get to the heating mats, cut the hog rings and peel the coverings up as far as they’ll go.

Here are a handful of the new heater components with their model numbers.

Rick Muscoplat was born in the year 2012.

Heated seat inoperable

TSB 09-4-8 is a technical service bulletin. HEATED SEAT(S) THAT ARE NOT IN OPERATION – BUILT BEFORE 12/14/2007 FORD: Five Hundred, Freestyle from 2005 to 2007. Taurus X (2008 model year), Taurus MERCURY is in the year 2005-2007. Sable Montego 2008 Montego2008 Sable ISSUE There are certain Freestyle, Five Hundred, Montego, and 2008 Taurus and Taurus X vehicles made before December 14, 2007 that may have a non-functioning heated seat (s). This may be due to an occasional open element in the heated seat pad, which is causing the problem.

  1. SERVICE OPERATING PROCEDURE This system is controlled by the heated seat module, which is placed beneath the front passenger seat cushion in the front passenger seat.
  2. In order to manage seat temperature, the heated seat module uses a thermistor type thermostat situated in the cushion heating mat to monitor resistance and adjust the seat temperature.
  3. For cars manufactured before to January 1, 2006, the module will time out and shut down after 10 minutes.
  4. 2.
See also:  Replace tire valve caps?

If the resistance of the heater mats and circuits for an intermittent open are being tested, technicians should sit in the seat while testing the circuit resistance, move the seat in multiple seating positions, and apply pressure to several areas of the heated seat mat to ensure that the mat element is not opening intermittently.

2.

NEW VEHICLE LIMITED WARRANTY COVERAGE: Eligible under the terms of the New Vehicle Limited Warranty Coverage IMPORTANT: A TSB has no effect on the coverage limitations or policies of a warranty.

The warranty coverage limitations are defined by the causative part that has been identified. DEALER CODING CONDITIONBASIC PART NO. CODE 14D696 28 DEALER CODING CONDITION

Drivers side seat heater not working

If you purchased it from a Ford dealer’s used car lot, or any other new car dealer’s used car lot for that matter, you should return it to that dealer and ask them to repair the vehicle. This should be covered by the bare minimum warranty (one month and 3000 miles, perhaps?) that you would receive on a used vehicle. Especially if the dealer was a Ford dealership, they should be humiliated for having sold you a late model Ford with a significant system that was not functioning. This would be like to selling you a secondhand automobile with a broken headlight or a malfunctioning cruise control.

  1. While they would almost certainly test items like the headlights and cruise control before putting it up for sale, it’s possible that they would not have thought to test the heated seats, which is another reason to bring it to their notice.
  2. If everything checks OK, it’ll most likely be sent to a Ford dealer for repair because it will entail removing the seat and replacing the heating unit on the interior of it.
  3. $400 to $500 is a reasonable estimate.
  4. By the way, how many kilometers do you have on your vehicle?
  5. If this is the case, it makes no difference who sold it to you.

Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle OEM • $25.53

Seller:quirkparts✉️(859,978) Location: Braintree, Massachusetts, United States, 98.9 percent Ships to: United States a number of other countries Item:192229301819 From 2005 to 2007, the Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle was available. Ford Freestyle is a sports car manufactured by Ford. The Left Hand Driver’s Side Seat Back Adjuster Handle is a straight replacement for the following models: Condition:New, Brand:Ford, Manufacturer Part Number:5F9Z-74620A91-AAA, OEM/Original Equipment Manufacturer Part Number:5F9Z-74620A91-AAA, Model:Freestyle Five Hundred Montego, Manufacturer Warranty:1 Year Certifications:OE, Direct replacement is the most common type of installation.

Item that has been modified: No, No, this is not a non-domestic product.

Medium Pebble is the surface finish.

PicClick Insights – Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle OEMPicClick Exclusive

  • Popularity – 39 people are watching this, 30 days on eBay. The number of people that are watching is really high. 192 units sold, 5 units remaining

Popularity – Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle OEM

  • 39 people are watching this item, and it has been on eBay for 30 days. The number of people that are watching is really high. 192 units sold, 5 units remaining
  • Best Price-

Price – Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle OEM

  • Seller has sold over 859,978 items. Negative responses accounted for 1.1 percent. Plus, it’s the best! Top-Rated Seller with a 30-day return policy and shipping that is completed in one business day with tracking

Seller – Ford Freestyle Five Hundred Montego LH Driver Seat TAN Back Adjuster Handle OEM

More than 859,978 products have been sold.

Negative responses accounted for 1.1 percent. Plus, it’s the best! Seller with a high rating, a 30-day refund policy, and a shipping time of one business day with tracking.

Recent Feedback
  • $25.88 Buy It Now27d 7h
  • $19.64 Buy It Now Buy It Now30d 2h
  • $12.30 Buy It Now Buy It Now11d 12h
  • $17.95 Buy It Now Buy It Now10d 7h
  • $12.28 Buy It Now Buy It Now11d 12h
  • $18.99 Buy It Now Buy It Now14d 6h
  • $20.00 Buy It Now Buy It Now4d 2h
  • $27.73Buy It Now4d 2h
  • $27.73Buy It Now4d 2hBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It NowBuy It Now Buy It Now29d 21h
  • $19.99 Buy It Now Buy It Now in 7 days and 7 hours for $31.27 Buy It Now30d 21h
  • $23.88 Buy It Now Buy It Now11d 18h
  • $9.79Buy It Now11d 18h
  • $9.79 Buy It Now (29d 13h
  • $50.00) 29d 13h Buy It Now2d 23h
  • $9.48 Buy It Now2d 23h
  • $9.48 Buy It Now (29d 15h
  • $3.88) 29d 15h Buy It Now28d 15h
  • $19.96 Buy It Now Buy It Now25d 20h
  • $15.00 Buy It Now 29 days and 18 hours left to buy it
  • $29.00 Buy It Now4 days and 2 hours
  • $24.90 Buy It Now16d 5h
  • $22.95Buy It Now16d 5h
  • $22.95 Buy It Now17d 21h
  • $26.92 Buy It Now Buy It Now24d 22h
  • $45.99Buy It Now27d 22h
  • $45.99Buy It Now24d 22h
  • $45.99Buy It Now24d Buy It Now27d 22h
  • $23.95Buy It Now16d 19h
  • $23.75Buy It Now27d 22h
  • $23.95Buy It Now27d 22h
  • $23.95Buy It Now16d Buy It Now20d 20h
  • $60.00Buy It Now20d 20h Buy It Now3d 19h
  • $49.33 Buy It Now3d 19h $79.00 Buy It Now (27d 1h left). Buy It Now2d 5h
  • $78.99Buy It Now27d 22h
  • $78.99Buy It Now2d 5h
  • $78.99Buy It Now2d
See also:  Wheel Wobbles while driving?

2007 Ford Freestyle Seat Heater Pad – 5F9Z14D696B

5F9Z14D696B is the part number for this. The following are supersession(s): 5F9Z-14D696-B; 5F9Z-14D696-BA; 5F9Z-14D696BAS; 5F9Z-14D696BAS Heater. Something to eat. Cushion is an element. Bucket in the second row. Pad for the seat heater. Assembly – Heating pad for the back. BUCKET FOR FIVE HUNDRED AND FIVE THOUSAND, FREESTYLE, TAUrus, TAUrus X2ND ROW Montego Bay; Five Hundred; Lower; Five Hundred; Montego Bay Freestyle; a lower pitch. Taurus X; Front Seat; Seat Cushion; Leather Interior. Taurus X; Rear Seat; Seat Cushion; Leather Interior.

Seat Heater: Should it be repaired or replaced?

Is the upholstery torn or singed in any way?

Provide your 2007 Ford Freestyle with a diagnostic and replacement seat heating control module by a qualified technician.

  • 5F9Z14D696B is the part number. There are three 5F9Z-14D696-B supersessions, five 5F9Z-14D696-BA supersessions, and five 5F9Z-14D696BAS supersessions. Then there’s the heating system. Cushion. An element. BUCKET IN THE THIRD ROW Heating pad for the seat The heating pad and the back pad are assembled. BUCKET FOR FIVE HUNDRED AND FIVE THOUSAND, FREESTYLE, TAURAN, TAURAN X2ND ROW Montego Bay
  • Five Hundred
  • Lower. Reduced in size and weight
  • Freestyle a Taurus X with a front seat cushion Interior of the Taurus X
  • Rear seat
  • Seat cushion. Cushion for the seat in Taurus and Sable. Should you repair or replace your seat heater? You’ve noticed that your seat warmer isn’t heating up anymore. Is the upholstery torn or singed in any places? You may have experienced a failure of your electric seat heaters Provide your 2007 Ford Freestyle with a diagnostic and replacement seat heating control module by a professional.

Cloth, leather, and other materials non-locking. Seats may be adjusted. Tan leatherette seat memory. with memory seat, without memory seat, without power recliner, with power recliner, black the period from 12/15/07 gray. to 12/13/07 5692 Front left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, left, Htr for the seat cushion.

  1. There is no locking.
  2. CENTER.
  3. RIGHT.
  4. cloth, leather on the inside of the door, and leather on the inside of the door.
  5. Tan leather seat adjuster.
  6. the date ranges from 4/08/08 gray to 4/7/08 5692 Right in front of me.
  7. Htr for the seat cushion.
  8. The outboard is non-locking.
  9. stone.
  10. RIGHT.
  11. Heater for the seat.

Fulfillment Options

Lakeland Ford Online Parts is an online store that sells Ford parts. A location at 1430 West Memorial Blvd. in Lakeland, FL 33815

LAKELAND FORD PARTS

A location at 1430 West Memorial Blvd. in Lakeland, FL 33815 SPWEB34’s email address is not valid.

Ford Five Hundred/Mercury Montego Maintenance & Repair – Page 4

My vehicle is a 2005 LTD. I purchased it brand new (I purchased the extended warranty because it was a new model year, but I haven’t had to use it yet). With all of the recent discounts, I began to consider purchasing a new vehicle and went car shopping. Fortunately, I reside in a tiny town (about 60,000 people), and the individuals that work at our local Ford dealership are really honest and straightforward. I spoke with the salesperson about exchanging in this vehicle for something that would cost around the same amount per month (I still have one year of payments remaining).

  • My automobile is equipped with all of the bells and whistles (sun roof, heated seats, leather interior, it goes on and on).
  • My dealer was quite forward and honest with me.
  • He stated that this engine should provide me with 200,000 to 250,000 miles of service and that the gearbox (CVT) should be trouble free.
  • I’ve had the brakes fixed (remember the rear brake recall from earlier) and I did have an issue with the driver’s side seat warmer, which attempted to burn up my seat (literally).
  • That’s all there is to it!
  • This is something I plan to preserve till the wheels come off of it.
  • anyone who is thinking about purchasing a Five Hundred.

Don’t allow the fact that they didn’t make it deter you from trying. Taking advantage of the low price (which is only possible since they ceased using the name Five Hundred – it is now Taurus) is a good idea. I’m still in love with my Five Hundred.

2005-07 Ford Freestyle

Any Freestyle is slow on takeoff, but it performs admirably after that. A test AWD Limited went from 0-60 mph in 8.7 seconds. As a result, passing responsiveness is improved since the CVT allows engine speed to race ahead of road speed. With a towing capability of 2000 lb, this midsize SUV is on the low side for its class. A test AWD Limited achieved an average fuel economy of 18.7 mpg, which included gas-guzzling performance runs. An AWD SEL achieved an average fuel economy of 19.7 mpg in a combination of city and highway driving.

  • Freestyle makes use of regular-grade gasoline.
  • Freestyle’s car-like base is beneficial in this regard, as it is also beneficial in terms of steering and handling responsiveness.
  • It’s also a pretty quiet SUV, with a level of refinement comparable to that of other car-type vehicles.
  • Reservations for cabins are slightly better than usual for the class.
  • The gauges are straightforward and easy to see, but the temperature controls are too low to be used safely while driving.
  • Except for the really tall, there is plenty of head and leg room.
  • Only a few vehicles are equipped with 2nd-row seats that may be moved forward or backward to expand luggage capacity or passenger space.
  • When transporting freight, the fold-flat front-passenger seat is a convenient feature that allows the load deck to be extended to 9.5 ft.
  • Interior storage is excellent, with a large console and dashtop containers to accommodate a large amount of little items.
See also:  Honda code P1298?

Ford TSB: 09-4-8 INOPERATIVE HEATED SEAT(S)

TSB 09-4-803/09/09 TSB 09-4-803/09/09 INOPERATIVE HEATED SEAT(S) – CONSTRUCTED PRIOR TO 12/14/2007 FORD: Five Hundred and Freestyle from 2005 to 2007. Taurus X (2008 model year), Taurus MERCURY:2005-2007 Montego2008 SableISSUE Montego2008 There are certain Freestyle, Five Hundred, Montego, and 2008 Taurus and Taurus X vehicles made before December 14, 2007 that may have a non-functioning heated seat (s). This may be due to an occasional open element in the heated seat pad, which is causing the problem.

  1. SERVICE OPERATING PROCEDURE This system is controlled by the heated seat module, which is placed beneath the front passenger seat cushion in the front passenger seat.
  2. In order to manage seat temperature, the heated seat module uses a thermistor type thermostat situated in the cushion heating mat to monitor resistance and adjust the seat temperature.
  3. For cars manufactured before to January 1, 2006, the module will time out and shut down after 10 minutes.
  4. 2.

If the resistance of the heater mats and circuits for an intermittent open are being tested, technicians should sit in the seat while testing the circuit resistance, move the seat in multiple seating positions, and apply pressure to several areas of the heated seat mat to ensure that the mat element is not opening intermittently.

2.

Block of Parts WARRANTY STATUS: Eligible for coverage under the terms of the New Vehicle Limited Warranty.

The warranty coverage limitations are defined by the causative part that has been identified.

DESCRIPTION OF THE OPERATION TIME Utilize SLTS operations when they are available or labor time when it is performed as actual time in MT090408. DEALER CODINGCONDITIONBASIC PART NO. CODE14D696 28 DEALER CODINGCONDITIONBASIC PART NO. CODE14D696 28

2006 Ford Freestyle Specs, Price, MPG & Reviews

Technical Service Bulletin 09-4-803/09/09 (TSB 09-4-803) BUILT-BEFORE – INOPERATIVE HEATED SEAT(S) 12/14/2007 Five Hundred, Freestyle (2005-2007) FORD: 2007 Toyota Taurus X, Taurus X-Trailer MERCURY:2005-2007 Issue Montego 2008 Sable Montego 2008 Sable There are certain Freestyle, Five Hundred, Montego, and 2008 Taurus and Sable vehicles made before December 14, 2007 that may have an inoperative heated seat (s).

  1. Possibly, an occasional open element in the heated seat pad is the source of this worry.
  2. METHOD OF APPLICATION The heated seat system is controlled by a heated seat module, which is placed beneath the front passenger seat cushion of the vehicle.
  3. Using a thermoistor type thermostat, which is situated in the cushion heater mat, the heated seat module maintains a constant seat temperature by measuring resistance.
  4. It will time out and shut down after 10 minutes in vehicles manufactured prior to May 1, 2006.

If the resistance of the heater mats and circuits for an intermittent open are being tested, technicians should sit in the seat while testing the circuit resistance, move the seat in multiple seating positions, and apply pressure to several areas of the heated seat mat to ensure that the mat element is not opening intermittently.

Block of Components Eligible for coverage under the provisions of the New Vehicle Limited Warranty Coverage.

It is the identified causative component that determines the warranty coverage limitations.

CAR DEALER CODINGCONDITIONBASIC PART NUMBER CODE14D696 28 CAR DEALER CODINGCONDITIONBASIC PART NUMBER CODE14D696 28

Leave a Comment

Your email address will not be published. Required fields are marked *