fusecheck.com
- The passenger’s compartment fuse block can be found behind the kick panel under and slightly to the left of the steering wheel. In case You don’t have a diagram, fuse #10 is a 30A fuse located on the third column from the right, third fuse from the top.
Where are the fuses located on a 2009 Ford Fusion?
Usually located in or around the instrument panel near the dash, fuses can also be found under the hood and even under the rear seat. Next time your radio, lights or other device stops working, chances are a blown fuse is the culprit. Look under “Fuses” in your owner’s manual for help finding your fuse panels.
Where is the starter relay on a Ford Fusion?
The 2007 ford fusion starter relay is located on the firewall next to the fuse panel.
Where is the starter relay on a 2008 Ford Fusion?
The 2008 Ford Fusion does not have a starter relay; it instead shares fuse #10 in the passenger’s compartment with the powertrain control module (PCM). The passenger’s compartment fuse block can be found behind the kick panel under and slightly to the left of the steering wheel.
Where are the fuses and relays located?
The fuses and relays are often identified inside the power center cover.
How do you know if a fuse is blown?
Remove the fuse from its holder. In some cases you may need a small screwdriver to unscrew the fuse holder cap. Look at the fuse wire. If there is a visible gap in the wire or a dark or metallic smear inside the glass then the fuse is blown and needs to be replaced.
Where is the Ford Fusion sync fuse located?
The fuse panel is located under the instrument panel to the left of the steering column (behind the trim panel below the steering wheel).
How do you get to the passenger fuse box on a Ford Fusion?
To access the bottom of the fuse box, do the following:
- Release the two latches, located on both sides of the fusebox.
- Raise the inboard side of the fusebox from the cradle.
- Move the fusebox toward the center of the engine compartment.
- Pivot the outboard side of the fusebox to access the bottom side. Fuse box diagrams.
Which fuse is the sync fuse?
The SYNC fuse is located at position number 2, which is a 15 amp MINI fuse. It controls the SYNC display module, which in this case, is an 8 inch screen.
Where is the starter relay on a 2006 Ford Fusion?
The starter relay for the 2006 Ford Fusion is normally found in the fuse box. Most cars also have the starter relay located under the hood, inside a long box with a black cover on it. This is called the fuse boxAnd sometimes called the power boxAs well.
Where is the power steering fuse located on a 2011 Ford Fusion?
The power steering fuse in a 2011 Ford Fusion can be found in the fuse panel that is located against the firewall in the engine compartment. Since Your power steering motor is in Your engine bay it connects directly to this power distribution fuse box.
How do you reset the anti theft on a Ford Fusion?
Resetting your anti-theft system is as easy as turning your key in the ignition eight times in 10 seconds, leaving the last turn in the “run” position. Then, press and hold a button on the remote for 30 seconds to lock the vehicle.
Is a relay the same as a fuse?
Fuses are included on all your car’s various electrical circuits to protect components from surges of electricity. Relays are remote switches that open or close an electrical circuit. For example, only a little electricity is needed for the headlight switch that turns your headlights on and off.
Does a fuse go before or after a relay?
3 Answers. The fuse should always be the first thing a power supply hits when it gets to a circuit. The reason is pretty simple. In the event of a fault that blows the fuse, the power is isolated to where it entered the circuit, thus the whole circuit is protected.
Fuse Box Diagram Ford Fusion (2006-2009)
In this article, we’ll look at the first-generation Ford Fusion (US) before it had a facelift, which was built between 2006 and 2009. Here you will discover Ford Fusion fuse box schematics for the years 2006, 2007, 2008, and 2009, as well as information on the position of the fuse panels within the vehicle and the functions assigned to each fuse (fuse layout) and relay (relay assignment).
Fuse Layout Ford Fusion 2006-2009
In the Instrument panel fuse box, the cigar lighter (power outlet) fuse is fuse No15 (Cigar lighter), whereas the console power point fuse in the Engine compartment fuse box is fuse No17 (2006-2007) or No22 (2008-2009) (Console power point).
Passenger compartment
When you are driving, you will find your fuse panel below and to the left of your steering wheel near your brake pedal.
Engine compartment
The power distribution box is housed in the engine compartment of the vehicle.
2006, 2007
The fuses in the passenger compartment are assigned according to their function (2006, 2007)
| № | Amp Rating | Description |
|---|---|---|
| 1 | 10A | Backup lamps, Electrochromatic mirror |
| 2 | 20A | Horns |
| 3 | 15A | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Power windows |
| 4 | 15A | Parklamps, Side markers, License plate lamps |
| 5 | — | Not used |
| 6 | — | Not used |
| 7 | — | Not used |
| 8 | 30A | Rear window defroster |
| 9 | 10A | Heated mirrors |
| 10 | 30A | Starter coil, PCM |
| 11 | 15A | High beams |
| 12 | 7.5A | Delay accessories: Radio head units, Moonroof, Lock switch illumination, Electrochromatic mirrors |
| 13 | 7.5A | Cluster, KAM-PCM, Analog clock, Climate control head units, Canister vent solenoid |
| 14 | 15A | Washer pump |
| 15 | 20A | Cigar lighter |
| 16 | 15A | Door lock actuator, Decklid lock solenoid |
| 17 | 20A | Subwoofer |
| 18 | 20A | Radio head units, OBDII connector |
| 19 | — | Not used |
| 20 | 7.5A | Power mirrors |
| 21 | 7.5A | Stop lamps |
| 22 | 7.5A | Audio |
| 23 | 7.5A | Wiper relay coil, Cluster logic |
| 24 | 7.5A | OCS (Passenger’s seat), PAD indicator |
| 25 | 7.5A | RCM |
| 26 | 7.5A | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch |
| 27 | 7.5A | Cluster, Climate control head units |
| 28 | 10A | ABS/Traction Control, Heated seats, Compass |
| C/B | 30A Circuit Breaker | Power windows, Delayed accessory (SJB fuse!2) |
Engine compartment
Fuses in the passenger compartment are assigned to certain circuits (2006, 2007)
| № | Amp Rating | Description |
|---|---|---|
| 1 | 60A*** | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 40 A** | Powertrain power |
| 3 | — | Not used |
| 4 | 40 A** | Blower motor |
| 5 | — | Not used |
| 6 | 40 A** | Rear window defroster, Heated mirrors |
| 7 | 40 A** | PETA Pump (PZEV engine only) |
| 8 | — | Not used |
| 9 | 20A** | Wipers |
| 10 | 20A** | ABS Valves |
| 11 | 20A** | Heated seats |
| 12 | — | Not used |
| 13 | — | Not used |
| 14 | 15A* | Ignition switch |
| 15 | — | Not used |
| 16 | 15A* | Transmission |
| 17 | 20A* | Console power point |
| 18 | 10 A* | Alternator sense |
| 19 | 40 A** | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | 60A** | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 24 | 15A* | Fog lamps |
| 25 | 10 A* | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | — | Not used |
| 29 | 60A*** | Engine cooling fan |
| 30 | 30A** | Fuel pump relay feed |
| 31 | — | Not used |
| 32 | 30A** | Driver power seat |
| 33 | 20A** | Moonroof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 40 A** | ABS Pump |
| 37 | — | Not used |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | — | Not used |
| 42 | 15A* | PCM non-emission related |
| 43 | 15A* | Coil on plug |
| 44 | 15A* | PCM emission related |
| 45 | 5A* | PETA Pump feedback (PZEV engine only) |
| 46 | 15A* | Injectors |
| 47 | 1/2 ISO Relay | Fog lamps |
| 48 | — | Not used |
| 49 | — | Not used |
| 50 | 1/2 ISO Relay | Wiper Park |
| 51 | 1/2 ISO Relay | A/C Clutch |
| 52 | — | Not used |
| 53 | 1/2 ISO Relay | Wiper RUN |
| 54 | 1/2 ISO Relay | Transmission (l4 engine only) |
| 55 | Full ISO Relay | Fuel pump |
| 56 | Full ISO Relay | Blower motor |
| 57 | Full ISO Relay | PCM |
| 58 | High Current Relay | PETA Pump (PZEV engine only) |
| 59 | — | Not used |
| 60 | Diode | Fuel pump |
| 61 | Diode | Not used |
| 62 | Circuit Breaker | Spare |
| * Mini fuses ** A1 fuses *** A3 fuses |
2008, 2009
The fuses in the passenger compartment are assigned according to their function (2008, 2009)
| № | Amp Rating | Description |
|---|---|---|
| 1 | 10A | Backup lamps (automatic transmission), Electrochromatic mirror |
| 2 | 20A | Horns |
| 3 | 15A | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Power windows |
| 4 | 15A | Parklamps, Side markers, License plate lamps |
| 5 | — | Not used |
| 6 | — | Not used |
| 7 | — | Not used |
| 8 | 30A | Rear window defroster |
| 9 | 10A | Heated mirrors |
| 10 | 30A | Starter coil, PCM |
| 11 | 15A | High beams |
| 12 | 7.5A | Delay accessories: Radio head units, Moon roof, Lock switch illumination, Electrochromatic mirrors, Ambient lighting |
| 13 | 7.5A | Cluster, Analog clock, Climate control head units |
| 14 | 15A | Washer pump |
| 15 | 20A | Cigar lighter |
| 16 | 15A | Door lock actuator, Decklid lock solenoid |
| 17 | 20A | Subwoofer |
| 18 | 20A | Radio head units, OBDII connector |
| 19 | 7.5A | Not used (Spare) |
| 20 | 7.5A | Power mirrors, Satellite radio module, All wheel drive |
| 21 | 7.5A | Stop lamps, CHMSL |
| 22 | 7.5A | Audio |
| 23 | 7.5A | Wiper relay coil, Cluster logic |
| 24 | 7.5 A | OCS (Passenger’s seat), PAD indicator |
| 25 | 7.5 A | RCM |
| 26 | 7.5 A | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch, Automatic transmission relay coil, Reverse switch (back-up lamps for manual transmission) |
| 27 | 7.5 A | Cluster, Climate control head units |
| 28 | 10 A | ABS/Traction Control, Heated seats, Compass, Reverse sensing system |
| C/B | 30A Circuit Breaker | Moon roof power, Delayed accessory (SJB fuse 12, power window) |
Engine compartment
The fuses in the power distribution box are assigned to certain circuits (2008, 2009)
| № | Amp Rating | Description |
|---|---|---|
| 1 | 60A*** | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 60A*** | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 3 | 40A** | Powertrain power, PCM relay coil |
| 4 | 40A** | Blower motor |
| 5 | — | Not used |
| 6 | 40A** | Rear window defroster, Heated mirrors |
| 7 | 40A** | PETA Pump (PZEV) power feed |
| 8 | 40A** | ABS pump |
| 9 | 20A** | Wipers |
| 10 | 30A** | ABS Valves |
| 11 | 20A** | Heated seats |
| 12 | — | Not used |
| 13 | 10 A* | SYNC |
| 14 | 15 A* | Ignition switch |
| 15 | — | Not used |
| 16 | 15 A* | Transmission |
| 17 | 10 A* | Alternator sense |
| 18 | — | Not used |
| 19 | 40A** | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | 20A** | Console power point |
| 23 | 10 A* | PCM KAM, FNR5 and canister vent solenoid |
| 24 | 15 A* | Fog lamps |
| 25 | 10 A* | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 60A*** | Engine cooling fan |
| 29 | — | Not used |
| 30 | 30A** | Fuel pump/injectors relay |
| 31 | — | Not used |
| 32 | 30A** | Driver power seat |
| 33 | 20A** | Moon roof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 1A* | PCM diode |
| 37 | 1A* | One Touch Integrated Start (OTIS) diode (Automatic transmission only) |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | Relay | Fog lamp relay |
| 42 | Relay | Wiper park relay |
| 43 | Relay | A/C clutch relay |
| 44 | Relay | FNR5 transmission relay |
| 45 | 5A* | PETA Pump (PZEV) feedback |
| 46 | 15 A* | Injectors |
| 47 | 15 A* | PCM class B |
| 48 | 15 A* | Coil on plug |
| 49 | 15 A* | PCM class C |
| 50 | — | Not used |
| 51 | — | Not used |
| 52 | Full ISO Relay | Blower relay |
| 53 | — | Not used |
| 54 | Full ISO Relay | Fuel pump/injectors relay |
| 55 | Full ISO Relay | Wiper RUN relay |
| 56 | — | Not used |
| 57 | Full ISO Relay | PCM relay |
| 58 | High Current Relay | PETA Pump (PZEV) |
| * Mini fuses ** A1 fuses *** A3 fuses |
2009 Ford Fusion Fuse Diagram
The fuses in the power distribution box have been assigned (2008, 2009)
There’s lots more information on this site for your vehicle.To find fuse diagrams,click hereTo find Relay locations,click hereTo find Sensor Locations,click hereTo find Module Locations,click hereTo find Switch Locations,click hereTo find Firing Order,click here
Box for the battery of a Ford Fusion model number 009 Power Steering Control Module with MIDI (WH) input and output (PSCM) Smart Junction Box with 125A MIDI (PK) capability (SJB) 1 15A (1) Mirror with a heating element 2 30A (2) Defroster in the Rear 3 20A (2) Power Outlets on the Rear (Center Console) 4 – Is not in use 5 10A (1) Keep Alive Power (PCM); EVAP Canister Vent Control Solenoid, PCM; EVAP Canister Vent Control Solenoid, PCM Power (1) Relay6 with 15A capacity (1) Generator7 with 10A capacity (1) The Liftgate Lock Relay8 20A is used to lock the liftgate (1) Lamps for trailer tow parking lots The anti-lock braking system is controlled by Relay9 50A (2).
(ABS) A/C Clutch Relay14 15A (1) Trailer Tow Turn Relay (Left and Right) Module10 30A (2) Windshield Wiper Motor11 30A (2) Starter Relay12 40A (2) Blower Motor Relay13 10A (1) A/C Clutch Relay, Left and Right 15 – This number is not used.
25 – This number has not been used (1) Coil on Plug (COP) 1, 2, 3, 4, 5, and 6; Ignition Transformer Capacitor Switch; Evaporative Emission (EVAP) Canister Purge Valve; Variable Camshaft Timing (VCT)Valve; Heated Oxygen Sensor (HO2S)11, 12, 21, and 22; EGR Stepper Motor; Mass Airflow/Intake Air Temperature (MAF/IAT) Sensor; Variable Camshaft Timing (VCT)Valve; (VCT) (1) Powertrain Control Module with valves 1, 2, and 29 (15A) (PCM) One Touch Integrated Start Diode34 One Touch Integrated Start Diode35 One Touch Integrated Start Diode (1) Front and rear window defrost relays, Reverse Lamp Relay27 10A (2), Floor Shifter, and Heated Positive Crankcase Ventilation are all included with the package (PCV) Valve28 20A (1) Powertrain Control Module (PCM), Brake Pedal Position, Valve28 20A (1) Powertrain Control Module (PCM), Brake Pedal Position
2009 Ford Fusion Fuse Diagram for Smart Junction Box
Smart junction box for the 2009 Ford Fusion 1 30A Is Not In Use (SPARE) 2 15 A Switch for the Brake Pedal Position 3 15A Accessory Protocol Interface Module is a protocol interface module for the Accessory Protocol (APIM) Roof opening Panel Module with four 30A circuits 5A Keypad Illumination, Brake Shift Interlock, and a 10A Power Supply The SJB6 20A Park/Stop/Turn lamp is available in two versions: LR and RR, Park/Stop/Turn lamp (LF and RF), and Side Turn Signal Lamps.
7.1 10A Low Beam with Left Headlamp Lights: 8 10A low beam, headlamp on the right 9 15A Cargo Lamps, Interior/Map Lamps, and Interior Lamps are available.
Control Module with 11 10A 4 4 wires 12 Switch for the rear view mirror on the outside of the house that draws 7.5 amps 13 EVAP Canister Vent with a 7.5A rating Solenoid The FCIM (Radio Buttons), SDARS module, and Front Display Interface Module are all rated at 10A.
24 20A Horn Relays, Horn Switches, and Horn Contactors The following items are included: 25 10A Battery Saver Relay; Cargo Light; Interior/Map Lamp; Interior Lamp; Vanity Mirrors 26 10A Instrument Cluster (IC)27 20A Ignition Switch28 5A Audio Control Module 26 10A Instrument Cluster (IC)27 20A Ignition Switch (ACM) 30 5A Floor Shifter 29 5A Instrument Cluster (IC) 30 5A Instrument Cluster (IC) 31 10A Restraint Control Module (RCM)32 10A Not in Use 31 10A Not in Use (SPARE) Switch for the steering wheel and speed control (33 10A) 34 Module for the Anti-lock Braking System (ABS) with a 5A ABS Test Connector 35 10A Parking Aid Module, 4WD Control Module, and Power Steering Control Module are all available options (PSCM) 36 5A PATS Transceiver37 10A PATS Transceiver HVAC-EMTC, HVAC-DATC are abbreviations for HVAC-Emergency Maintenance and Repair.
The following components are powered by 20A: 38 20A subwoofer amplifier39 20A audio control module (ACM), audio amplifier40 20A power point Door lock switches, the Ambient Lighting Module, the Roof Opening Panel Module and the Electrochromatic Rear View Mirror are all included in the 41 15A Driver/Passenger circuits.
Rick Muscoplat posted a blog entry on
2006-2009 Ford Fusion Fuse Box Diagram
| FordFusion | |||
| USA | Europe | ||
| 2006-2009 | 2010-2012 | 2013-present | 2002-2012 |
Passenger Compartment Fuse Box
| No. | A | Circuits protected |
| 1 | 10 | Backup lamps (automatic transmission), Electrochromatic mirror |
| 2 | 20 | Horns |
| 3 | 15 | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Power windows |
| 4 | 15 | Parklamps, Side markers, License plate lamps |
| 5 | — | Not used |
| 6 | — | Not used |
| 7 | — | Not used |
| 8 | 30 | Rear window defroster |
| 9 | 10 | Heated mirrors |
| 10 | 30 | Starter coil, PCM |
| 11 | 15 | High beams |
| 12 | 7.5 | Delay accessories: Radio head units, Moon roof, Lock switch illumination, Electrochromatic mirrors, Ambient lighting |
| 13 | 7.5 | Cluster, Analog clock, Climate control head units |
| 14 | 15 | Washer pump |
| 15 | 20 | Cigar lighter |
| 16 | 15 | Door lock actuator, Decklid lock solenoid |
| 17 | 20 | Subwoofer |
| 18 | 20 | Radio head units, OBDII connector |
| 19 | 7.5 | Not used (Spare) |
| 20 | 7.5 | Power mirrors, Satellite radio module, All wheel drive |
| 21 | 7.5 | Stop lamps, CHMSL |
| 22 | 7.5 | Audio |
| 23 | 7.5 | Wiper relay coil, Cluster logic |
| 24 | 7.5 | OCS (Passenger’s seat), PAD indicator |
| 25 | 7.5 | RCM |
| 26 | 7.5 | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch, Automatic transmission relay coil, Reverse switch (back-up lamps for manual transmission) |
| 27 | 7.5 | Cluster, Climate control head units |
| 28 | 10 | ABS/Traction Control, Heated seats, Compass, Reverse sensing system |
| C/B | 30 | Circuit Breaker:Moon roof power, Delayed accessory (SJB fuse 12, power window) |
Engine Compartment Fuse Box (2006)
| No. | A | Circuits protected |
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 40 | Powertrain power |
| 3 | — | Not used |
| 4 | 40 | Blower motor |
| 5 | — | Not used |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV engine only) |
| 8 | — | Not used |
| 9 | 20 | Wipers |
| 10 | 20 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | Not used |
| 13 | — | Not used |
| 14 | 15 | Ignition switch |
| 15 | — | Not used |
| 16 | 15 | Transmission |
| 17 | 20 | Console power point |
| 18 | 10 | Alternator sense |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | — | Not used |
| 29 | 50 | Engine cooling fan |
| 30 | 30 | Fuel pump relay feed |
| 31 | — | Not used |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moonroof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 40 | ABS Pump |
| 37 | — | Not used |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | — | Not used |
| 42 | 15 | PCM non-emission related |
| 43 | 15 | Coil on plug |
| 44 | 15 | PCM emission related |
| 45 | 5 | PETA Pump feedback (PZEV engine only) |
| 46 | 15 | Injectors |
| 62 | – | Circuit Breaker:Spare |
| Diode | ||
| 60 | Fuel pump | |
| 61 | Not used | |
| Relay | ||
| 47 | Fog lamps | |
| 48 | Not used | |
| 49 | Not used | |
| 50 | Wiper Park | |
| 51 | A/C Clutch | |
| 52 | Not used | |
| 53 | Wiper RUN | |
| 54 | Transmission (I4 engine only) | |
| 55 | Fuel pump | |
| 56 | Blower motor | |
| 57 | PCM | |
| 58 | PETA Pump (PZEV engine only) | |
| 59 | Not used |
Engine Compartment Fuse Box (2007-2009)
| No. | A | Circuits protected |
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 3 | 40 | Powertrain power, PCM relay coil |
| 4 | 40 | Blower motor |
| 5 | — | Not used |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV) power feed |
| 8 | 40 | ABS pump |
| 9 | 20 | Wipers |
| 10 | 30 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | Not used |
| 13 | 10 | SYNC |
| 14 | 15 | Ignition switch |
| 15 | — | Not used |
| 16 | 15 | Transmission |
| 17 | 10 | Alternator sense |
| 18 | — | Not used |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | 20 | Console power point |
| 23 | 10 | PCM KAM, FNR5 and canister vent solenoid |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 60 | Engine cooling fan |
| 29 | — | Not used |
| 30 | 30 | Fuel pump/injectors relay |
| 31 | — | Not used |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moon roof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 1 | PCM diode |
| 37 | 1 | One Touch Integrated Start (OTIS) diode |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 45 | 5 | PETA Pump (PZEV) feedback |
| 46 | 15 | Injectors |
| 47 | 15 | PCM class B |
| 48 | 15 | Coil on plug |
| 49 | 15 | PCM class C |
| Relay | ||
| 41 | Fog lamp relay | |
| 42 | Wiper park relay | |
| 43 | A/C clutch relay | |
| 44 | FNR5 transmission relay | |
| 50 | Not used | |
| 51 | Not used | |
| 52 | Blower relay | |
| 53 | Not used | |
| 54 | Fuel pump/injectors relay | |
| 55 | Wiper RUN relay | |
| 56 | Not used | |
| 57 | PCM relay | |
| 58 | PETA Pump (PZEV) |
Fuse box Ford Fusion sedan 2006-2012
For the Ford Fusion car from the model years 2006, 2007, 2008, 2009, 2010, 2011, and 2012.
The fuse box is located in the passenger compartment. The position of the fuse box When you are driving, you will find your fuse panel below and to the left of your steering wheel near your brake pedal. To gain access to the fuses, remove the panel cover. schematic of a fuse box with legend
| Fuse | Amps | Circuits protected |
| F1 | 10 | Reversing lamps, Electrochromatic inside mirror unit |
| F2 | 20 | Horn |
| F3 | 15 | Interior Lamps, Luggage compartment lamp, Glove box lamp, puddle lamps, Vanity mirror lamp |
| F4 | 15 | Park lamps, Side lamps, License plate lamps |
| F5 | – | not used |
| F6 | – | not used |
| F7 | – | not used |
| F8 | 30 | Heated rear window |
| F9 | 10 | Heated mirrors |
| F10 | 30 | Starter motor, Powertrain Control Module (PCM) |
| F11 | 15 | Headlamps – High beams |
| F12 | 7.5 | Audio Control module, Roof opening panel, Power Door Locks, Power windows, Electrochromatic inside mirror unit |
| F13 | 7.5 | Instrument cluster, Powertrain Control Module (PCM), Clock, Manual climate control module, Electronic Automatic Temperature Control (EATC) module, Dual Automatic Temperature Control (DATC) module, EVAP canister vent control solenoid, FNR5 transmission |
| F14 | 15 | washer pump |
| F15 | 20 | Cigar lighter |
| F16 | 15 | Lock/unlock relays, Deck lid release relay |
| F17 | 20 | Subwoofer amplifier |
| F18 | 20 | Audio control module, Data Link Connector (DLC) |
| F19 | 7.5 | not used |
| F20 | 7.5 | Power mirrors, Satellite Digital Audio Receiver System (SDARS) module, Driver Door Module |
| F21 | 7.5 | Brake pedal position switch, Stop lamps, High mounted stop lamp |
| F22 | 7.5 | Audio Control module, Powertrain Control Module (PCM) |
| F23 | 7.5 | Wiper run/park relay, Instrument cluster, Blower motor relay |
| F24 | 7.5 | Occupant Classification Sensor (OCS), Hazard/PAD/Traction switch |
| F25 | 7.5 | Restraints control module |
| F26 | 7.5 | Passive anti-theft transceiver module, Powertrain Control Module (PCM), 6 Speed transmission, Reversing lamps switch |
| F27 | 7.5 | Instrument cluster, Manual climate control module, Electronic Automatic Temperature Control (EATC) module, Dual Automatic Temperature Control (DATC) module |
| F28 | 10 | ABS module, Heated seat module, Compass module, 4×4 module |
| C/3 | 30 | Power window motors, Accessory delay relay |
Ford Fusion fuse box located in the engine compartment. The power distribution box is housed in the engine compartment of the vehicle. The power distribution box is equipped with high-current fuses that safeguard the primary electrical systems of your car from being overloaded. The arrangement of the fuse box
| Fuse | Amps | Circuits protected |
| 1 | 60 | Smart Junction Box (SJB)-F12, F13, F14, F15, F16, F17, F18, F20, F21, Circuit breaker |
| 2 | 60 | Park lamp relay, Horn relay, F10, F11, F3 |
| 3 | 40 | PCM power relay |
| 4 | 40 | Blower motor relay |
| 5 | – | not used |
| 6 | 40 | Defrost relay |
| 7 | 40 | Secondary Air pump relay |
| 8 | 40 | ABS module |
| 9 | 20 | Wiper park relay, wiper run/park relay |
| 10 | 30 | ABS module |
| 11 | (1) 20(2) 30 | Heated seat module, Heated/cooled seat module |
| 12 | 30 | Heated/cooled seat module |
| 13 | 10 | Accessory Protocol Interface Module (APIM) |
| 14 | 15 | Ignition switch |
| 15 | 10 | Driver seat module, Seat control switch, driver side front |
| 16 | 15 | 6 Speed transmission, FNR5 relay |
| 17 | 10 | Generator |
| 18 | not used | |
| 19 | 40 | Smart Junction Box (SJB) logic |
| 20 | 20 | DSP Module |
| 21 | 20 | DSP Module |
| 22 | 20 | Power point |
| 23 | 10 | Powertrain Control Module (PCM), EVAP canister vent, FNR5 Trans |
| 24 | 15 | Fog lamp relay |
| 25 | 10 | A/C clutch relay |
| 26 | 15 | High intensity discharge headlamp relay, left |
| 27 | 15 | High intensity discharge headlamp relay, right |
| 28 | (1) 60 | Engine cooling fan motor |
| (2) 80 | Engine cooling fan motor | |
| 29 | – | not used |
| 30 | 30 | Fuel pump relay |
| 31 | 30 | Seat control switch, passenger side |
| 32 | 30 | Seat control switch, driver side, Driver seat module |
| 33 | 20 | Roof opening panel module |
| 34 | 30 | Power window motor, left front |
| 35 | 30 | Power window motor, right front |
| 36 | – | PCM diode |
| 37 | 1A* | One Touch Integrated Start (OTIS) diode (Automatic transmission only) |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | Relay | Fog lamp relay |
| 42 | Relay | Wiper park relay |
| 43 | Relay | A/C clutch relay |
| 44 | Relay | FNR5 transmission relay |
| 45 | 5A* | PETA Pump (PZEV) feedback |
| 46 | 15A* | Injectors |
| 47 | 15A* | PCM class B |
| 48 | 15A* | Coil on plug |
| 49 | 15A* | PCM class C |
| 50 | — | Not used |
| 51 | — | Not used |
| 52 | Full ISO Relay | Blower relay |
| 53 | — | Not used |
| 54 | Full ISO Relay | Fuel pump/injectors relay |
| 55 | Full ISO Relay | Wiper RUN relay |
| 56 | — | Not used |
| 57 | Full ISO Relay | PCM relay |
| 58 | High Current Relay | PETA Pump (PZEV) |
Ford Fusion (2006 – 2009) – fuse box diagram (American Version)
2006, 2007, 2008, and 2009 were the years of production.
Passenger Compartment Fuse Box
The following years were produced: 2006, 2007, 2008, and 2009.
| Number | Ampere ratting | Description |
| 1 | 10 | Backup lamps (automatic transmission), Electrochromatic mirror |
| 2 | 20 | Horns |
| 3 | 15 | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Power windows |
| 4 | 15 | Parklamps, Side markers, License plate lamps |
| 5 | — | — |
| 6 | — | — |
| 7 | — | — |
| 8 | 30 | Rear window defroster |
| 9 | 10 | Heated mirrors |
| 10 | 30 | Starter coil, PCM |
| 11 | 15 | High beams |
| 12 | 7,5 | Delay accessories: Radio head units, Moon roof, Lock switch illumination, Electrochromatic mirrors, Ambient lighting |
| 13 | 7,5 | Cluster, Analog clock, Climate control head units |
| 14 | 15 | Washer pump |
| 15 | 20 | Cigar lighter |
| 16 | 15 | Door lock actuator, Decklid lock solenoid |
| 17 | 20 | Subwoofer |
| 18 | 20 | Radio head units, OBDII connector |
| 19 | 7,5 | Not used (Spare) |
| 20 | 7,5 | Power mirrors, Satellite radio module, All wheel drive |
| 21 | 7,5 | Stop lamps, CHMSL |
| 22 | 7,5 | Audio |
| 23 | 7,5 | Wiper relay coil, Cluster logic |
| 24 | 7,5 | OCS (Passenger’s seat), PAD indicator |
| 25 | 7,5 | RCM |
| 26 | 7,5 | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch, Automatic transmission relay coil, Reverse switch (back-up lamps for manual transmission) |
| 27 | 7,5 | Cluster, Climate control head units |
| 28 | 10 | ABS/Traction Control, Heated seats, Compass, Reverse sensing system |
| C/B | 30 | Circuit Breaker:Moon roof power, Delayed accessory (SJB fuse 12, power window) |
Engine Compartment Fuse Box ( 2006 )
Ford Fusion – fuse box diagram – fuse box located in the engine compartment
| Number | Ampere ratting | Description |
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 40 | Powertrain power |
| 3 | — | — |
| 4 | 40 | Blower motor |
| 5 | — | — |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV engine only) |
| 8 | — | — |
| 9 | 20 | Wipers |
| 10 | 20 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | — |
| 13 | — | — |
| 14 | 15 | Ignition switch |
| 15 | — | — |
| 16 | 15 | Transmission |
| 17 | 20 | Console power point |
| 18 | 10 | Alternator sense |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | — |
| 21 | — | — |
| 22 | — | — |
| 23 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | — |
| 27 | — | — |
| 28 | — | — |
| 29 | 50 | Engine cooling fan |
| 30 | 30 | Fuel pump relay feed |
| 31 | — | — |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moonroof |
| 34 | — | — |
| 35 | — | — |
| 36 | 40 | ABS Pump |
| 37 | — | — |
| 38 | — | — |
| 39 | — | — |
| 40 | — | — |
| 41 | — | — |
| 42 | 15 | PCM non-emission related |
| 43 | 15 | Coil on plug |
| 44 | 15 | PCM emission related |
| 45 | 5 | PETA Pump feedback (PZEV engine only) |
| 46 | 15 | Injectors |
| 61 | — | Circuit Breaker:Spare |
| Diode | ||
| 60 | Fuel pump | |
| 61 | — | |
| Relay | ||
| 47 | Fog lamps | |
| 48 | — | |
| 49 | — | |
| 50 | Wiper Park | |
| 51 | A/C Clutch | |
| 52 | — | |
| 53 | Wiper RUN | |
| 54 | Transmission (I4 engine only) | |
| 55 | Fuel pump | |
| 56 | Blower motor | |
| 57 | PCM | |
| 58 | PETA Pump (PZEV engine only) | |
| 59 | — |
Engine Compartment Fuse Box ( 2007-2009 )
Diagram of the Ford Fusion’s fuse box in the engine compartment.
| Number | Ampere ratting | Description |
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 3 | 40 | Powertrain power, PCM relay coil |
| 4 | 40 | Blower motor |
| 5 | — | — |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV engine only) |
| 8 | 40 | ABS pump |
| 9 | 20 | Wipers |
| 10 | 20 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | — |
| 13 | 10 | SYNC |
| 14 | 15 | Ignition switch |
| 15 | — | — |
| 16 | 15 | Transmission |
| 17 | 10 | Alternator sense |
| 18 | — | — |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | — |
| 21 | — | — |
| 22 | 20 | Console power point |
| 23 | 10 | PCM KAM, FNR5 and canister vent solenoid |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | — |
| 27 | — | — |
| 28 | 60 | Engine cooling fan |
| 29 | — | — |
| 30 | 30 | Fuel pump/injectors relay |
| 31 | — | — |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moon roof |
| 34 | — | — |
| 35 | — | — |
| 36 | 1 | PCM diode |
| 37 | 1 | One Touch Integrated Start (OTIS) diode |
| 38 | — | — |
| 39 | — | — |
| 40 | — | — |
| 45 | 5 | PETA Pump (PZEV) feedback |
| 46 | 15 | Injectors |
| 47 | 15 | PCM class B |
| 48 | 15 | Coil on plug |
| 49 | 15 | PCM class C |
| Relay | ||
| 41 | Fog lamp relay | |
| 42 | Wiper park relay | |
| 43 | A/C clutch relay | |
| 44 | FNR5 transmission relay | |
| 50 | — | |
| 51 | — | |
| 52 | Blower relay | |
| 53 | — | |
| 54 | Fuel pump/injectors relay | |
| 55 | Wiper RUN relay | |
| 56 | — | |
| 57 | PCM relay | |
| 58 | PETA Pump (PZEV) |
WARNING: The terminal and harness assignments for particular connections will change based on the degree of vehicle equipment, the model, and the market in which the vehicle is sold.
Fuse box diagram Ford Fusion and relay with assignment and location
For the years 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, and 2011, a Ford Fusion subcompact van was constructed in Germany at a facility using gasoline and diesel engines displacing 1.2-1.4-1.6-liters. It was sold in the European Union as the Fusion subcompact van. During this time span, the automobile saw one styling revision. The Ford Fusion fuse boxes and relays are described in detail in our material, which also includes schematics and images of the fuse boxes and relays. Separately, we should mention the fuse that is in charge of the cigarette lighter.
The function of the boxes diagram elements may be different from what is seen in the illustration.
Also, if you have a Ford Fusion from a different generation (models from 2012), you should read this paper carefully.
Engine compartment
It is joined to the battery from the side, on the positive wire, and is made up of high-power fuse-links to protect the battery. Lifting the battery itself is required in order to have access to it. DiagramDesignation
| FА | 80A Auxiliary heater (heater RTS) |
| FB | 60A Gearbox |
| FC | 60A Auxiliary heater (RTS heater) / glow plugs (diesel engine) |
| FD | 40A Cooling fan and air conditioning |
| FE | 60A Lighting equipment and general electronic module (GEM) |
| FF | 60A Ignition |
| FG | 60A Engine and lighting equipment |
| FH | 60A Heated windshield, ABS, ESP, glass lifters |
Relay box
This unit, which has the shape of a square, is positioned adjacent to the battery. DiagramFunctions
- A / C shutdown at wide open throttle is performed by pressing R1. R2 is a high-speed engine cooling fan
- R3 is an auxiliary heater (RTS heater)
- R4 is an auxiliary heater (RTS heater)
- R5 is an auxiliary heater (RTS heater).
Passenger compartment
The main fuse and relay box, which is positioned in the passenger compartment beneath the glove compartment, is the most important component. For access, you must gently squeeze the sides of the walls together a little. The real task will be depicted as a diagram on the inside back cover of the book. DiagramAssignment
| F1 | Reserve |
| F2 | Trailer |
| F3 | Trailer |
| F4 | 10A Heating (air conditioning) and ventilation system |
| F5 | 20A Anti-lock braking system (ABS) |
| F6 | 30A Anti-lock braking system (ABS) |
| F7 | 15А Durashift EST gearbox |
| F8 | 7.5A Electric drive of outside rear-view mirrors |
| F9 | 10A Left low beam headlamp |
| F10 | 10A Right low beam headlamp |
| F11 | 15A Lighting when driving during daylight hours |
| F12 | 15A Power supply circuit of the injection system, ECU |
| F13 | 20A Engine management system (diesel) |
| F14 | 30A Starter |
| F15 | 20A Fuel pump |
| F16 | 3A Power supply circuit of the injection system relay, injection computer |
| F17 | 15A Switch for outdoor lighting |
| F18 | 15A Car radio |
| F19 | 15A Lighting when driving during daylight hours |
| F20 | 7.5A Instrument panel, shutdown timer, license plate light |
| F21 | Reserve |
| F22 | 7.5A Side light left side |
| F23 | 7.5A Side light right side |
| F24 | 20A Central locking and burglar alarm horn |
| F25 | 15A Hazard warning lights |
| F26 | 20A Heated rear window, tailgate |
| F27 | 15A Sound signal |
| F28 | 3A Battery, starter |
| F29 | 15ACigarette lighter |
| F30 | 15A Ignition system |
| F31 | 10A Switch of outdoor lighting devices |
| F32 | 7.5A Heated exterior mirrors |
| F33 | 7.5A Instrument Switch |
| F34 | Reserve |
| F35 | 7.5A Heated front seats |
| F36 | 30A Windows |
| F37 | 3A Anti-lock braking system (ABS) |
| F38 | 7,5А General purpose electronic unit |
| F39 | 7.5A Airbags |
| F40 | 7,5А automatic transmission |
| F41 | Reserve |
| F42 | 30A Heated windshield |
| F43 | 30A Heated windshield |
| F44 | 3A Car radio |
| F45 | 15A Stop lights |
| F46 | 20A Windshield wiper and washer |
| F47 | 10A Rear door glass wiper |
| F48 | 7,5A Reversing light |
| F49 | 30A Heater motor |
| F50 | 20A Fog lights |
| F51 | 15A auxiliary cigarette lighter fuse |
| F52 | 10A Left high beam headlamp |
| F53 | 10A Right high beam headlamp |
The cigarette lighter is controlled by fuse numbers 29 and 51 in the 15A circuitry. Please keep in mind that Gem is also in charge of the operation of the central locking system, the alarm, the turn signals, the wipers, the interior lighting, and the diagnostic system – which is positioned under the dashboard on the driver’s side, beneath the glove box – among other things. If you have any queries, feel free to post them in the comments section.